Author Topic: 175 Overheating  (Read 746 times)

0 Members and 1 Guest are viewing this topic.

Offline alexm846

  • Trade Count: (0)
  • Registered Bridgestone Member
  • **
  • Posts: 5
175 Overheating
« on: August 10, 2017, 07:10:03 AM »
Hey there,

I've got a '68 175DT that's recently made it out on the road for the first time in decades (it had been someones parts bike).  Runs pretty good at higher rpms and goes up to about 60MPH, but a little sloggy in the lower/acceleration. 

Anyway, after a 25 min ride, BOTH headers measured up to 250 degrees F.  Now I don't know what they should be, but I'm assuming that's considered very hot as the exhaust connectors burned up.  Why question is, what could cause this amount of overheating?  Is it possible for mixture, or clutch to do this, or are we talking something more?

Next question, I don't think related, although I had that it was until I realized both sides were heating up:

It's leaking gearbox oil from the drain hole behind the left cover.  For people who know these things inside and out: Is there something other than a case half leak that this could be?

Thanks for listening!!

Offline OldSwartout

  • Global Moderator
  • Trade Count: (0)
  • *******
  • Posts: 1051
Re: 175 Overheating
« Reply #1 on: August 10, 2017, 08:43:25 AM »

It's leaking gearbox oil from the drain hole behind the left cover.  For people who know these things inside and out: Is there something other than a case half leak that this could be?

Gearbox oil is collected and funneled into the oil pump drive case on the left rotary valve cover.  There is also a fill screw in the oil pump drive case below the oil pump.  Either the fill screw, one or both of the oil pump mounting screws or the oil pump drive case mounting bolts could be missing/loose or one of the gaskets could be damaged.
Karl Swartout
Mooresville, IN
BS175 Roadracer
BS350 GTR

Offline BRT-GTR

  • Brian
  • Trade Count: (0)
  • Master Registered Bridgestone Member
  • *****
  • Posts: 728
Re: 175 Overheating
« Reply #2 on: August 10, 2017, 03:51:01 PM »
             Two main causes of overheating are ;- 1) Weak mixture - main jet too small or partially blocked, carb needle in wrong slot, dirt in carb, float level too low, poor fuel flow from tank..
  2) Ignition timing too far advanced - adjust points gap and reset timimg to indent marks on the crank flywheel.

   Could be either cause, there are others as shown in the service manual. You were lucky you didn't melt a piston

     
Unspoiled by progress.

Offline alexm846

  • Trade Count: (0)
  • Registered Bridgestone Member
  • **
  • Posts: 5
Re: 175 Overheating
« Reply #3 on: August 10, 2017, 09:09:12 PM »
Thanks for the responses.  That's good news to me about the oil leak.  I'll have to probably do some trial and error with the overheating.  It's been a a while since I adjusted the timing and carbs.  I remember being pretty confident with the timing, because I re-did it several times, although I did not replace the points.  Thought I adjusted the carbs to spec, but I may try raising the floats or needles and see how that goes.

 


Gallery


Views:28
Comments (1)
By: killerterp

Views:33
Comments (0)
By: rwgibbon

Views:61
Comments (1)
By: fahrkle

Views:87
Comments (1)
By: Geoff S

Classifieds

1968 Restored BRIDGESTONE 175 Dual Twin

Price: $2900.00
Date: 07/11/2018 10:42 am
Time Left: 81d 15h 19m
UK registered Bridgestone 350GTR Original untouched bike

Price: £5900.00
Date: 07/07/2018 03:53 pm
Time Left: 77d 20h 29m
Bridgestone MK2 200ss
Price: £500.00
Date: 07/03/2018 02:29 pm
Time Left: 73d 19h 6m
BS Parts Cabinet & Mics Parts

Price: $0.00
Date: 06/21/2018 07:19 pm
Time Left: 61d 23h 56m

Recent Downloads added

Bridgestone Motorcycles

Rating: (None)
Filesize: 3561.91KB
Date: June 05, 2018, 04:42:13 PM
Bridgestone Magazine Article

Rating: (None)
Filesize: 3561.91KB
Date: June 05, 2018, 04:38:08 PM
How to build a 149 mph 350GTR....
Rating: (None)
Filesize: 7154.56KB
Date: April 18, 2017, 08:25:38 AM
Bert Lilley's BS 350 Racer Modifications
Rating: (None)
Filesize: 0KB
Date: January 09, 2017, 04:27:24 PM

Powered by EzPortal